Parts for your 2020 Ford Transit-Power steering hose

2020 Ford Transit power-steering-hose — is it actually a thing?

Short answer: no, a power-steering-hose isn’t used on the 2020 Ford Transit. According to Ford’s technical documentation, the 2020 model runs Electric Power-Assisted Steering (EPAS), not a hydraulic system. The Ford Workshop Manual for 2020 Transit (WSM, Section 211-00 Steering System – Electric Power-Assisted Steering) describes an electrically driven steering gear with an integrated motor and control module. The 2020 Transit Owner’s Manual also notes EPAS, and Ford’s parts catalogues for this model year list the steering gear, intermediate shaft and related fasteners, but no pressure or return power-steering-hose assemblies. That’s why anyone hunting a 2020-ford-transit/power-steering-hose will come up empty.

EPAS ditches the traditional pump, reservoir and hoses, using an electric motor to assist steering. That brings a few wins for owners and fleets in Australia and New Zealand: better fuel economy (no belt-driven pump), fewer leak points, and smarter integration with driver-assist tech like lane-keeping systems. It also means no fluid top-ups, no hose swell or chafe to worry about, and no hydraulic flushing intervals.

What should be serviced instead? On an EPAS-equipped 2020 Transit, the focus shifts to inspection and system health rather than hydraulics. During scheduled servicing, a workshop should:

• Check the steering rack boots for damage and the column/universal joints for play.
• Confirm alignment and tyre wear are even, as EPAS can mask minor geometry issues.
• Scan for EPAS fault codes if any steering warning messages appear, and road test for abnormal noises or assist variation.
• Verify battery and charging system condition — EPAS relies on clean, stable voltage.

If there’s fluid under the van, it won’t be power steering fluid on a 2020 Transit. Look instead at engine oil, transmission fluid, brake fluid, coolant, or the rear differential. For owners comparing parts online, note that earlier Transits (and some other Transit variants or older years) did use hydraulic power steering with hoses — that’s likely why hose listings still pop up in generic searches. But for the 2020 Ford Transit, a power-steering-hose simply isn’t part of the vehicle.

FAQs

Does the 2020 Ford Transit have a power-steering-hose?
No. The 2020 Transit uses Electric Power-Assisted Steering (EPAS), which has no hydraulic pump, reservoir or hoses. The steering assist is provided by an electric motor on the rack.

What do you service instead of a power-steering-hose on a 2020 Transit?
Inspect the EPAS rack boots, steering column joints, alignment and tyres, and confirm the battery/charging system are healthy. If a steering warning shows, have the system scanned for EPAS fault codes and road tested.

Why do some parts sites still list power steering hoses for my Transit?
Many listings are generic or apply to older Transits with hydraulic steering. The 2020 Ford Transit specifically uses EPAS, so a power-steering-hose isn’t applicable to this model year.