Parts for your 2002 Daihatsu Gran move-Brake shoes

2002 Daihatsu Gran Move brake shoes — are they relevant and what to know

Brake shoes are absolutely relevant to the 2002 Daihatsu Gran Move. Technical references including the Daihatsu Gran Move/Pyzar Workshop Manual for the G303/G313 series (Brake section – Rear), as well as the Daihatsu/Toyota Electronic Parts Catalogue for the same chassis range, specify rear drum brakes that use leading/trailing brake shoes and a hydraulic wheel cylinder. Major parts catalogues widely used in Australia and New Zealand (e.g., Bendix and Bosch) also list rear brake shoe sets for 1996–2002 Gran Move models. Front brakes are discs with pads, the rear axle uses drums with shoes.

On a 2002 Daihatsu Gran Move, the rear brake shoes do the hard yards inside the drum, pressing outwards to slow the car and also providing most of the handbrake holding force. Because they live inside the drum, they’re out of sight — so a bit of routine attention goes a long way. As part of regular servicing, they should be inspected for lining thickness, even wear, glazing, contamination and any signs of fluid from a weeping wheel cylinder.

Good practice on these is to replace brake shoes as a matched pair across the rear axle, and to have the drums measured and machined if needed, or replaced if out of spec. During the job, a tech should clean out brake dust, free up and lubricate the shoe contact points on the backing plate, check/clean the self-adjuster, and assess the condition of the return springs and handbrake cable. Any hint of fluid around the wheel cylinders calls for repair or replacement, then a proper bleed of the system.

Tell-tales it’s time to book it in:

• Longer handbrake lever travel or poor hill-holding
• Scraping or grinding from the rear, especially at low speed
• Rear-end pull, grabbing, or a pulsing pedal
• Brake warning lamp after fluid loss from a leaky cylinder

For most Gran Moves, a quick look every 12 months or 20,000 km suits typical Aussie and Kiwi driving. If the shoes are down to minimal lining, glazed, or oil-soaked, replacement is the go. After fitting, a careful bed-in with a few moderate stops helps the new linings settle to the drum. Don’t forget a check and adjust of the handbrake so it bites cleanly without excessive lever travel. Keeping the rear drums tidy means stronger, more consistent stopping and a handbrake that does its job when it counts.

Popular questions

Does the 2002 Daihatsu Gran Move use brake shoes or pads at the rear?
Yes — it uses brake shoes at the rear inside drum brakes, and pads at the front on disc brakes. The rear shoes also provide most of the handbrake holding force.

How often should the rear brake shoes be checked or replaced?
Have them inspected about every 12 months or 20,000 km. Replace when the lining is low, contaminated, glazed, uneven, or if the drums are out of spec or wheel cylinders are leaking.

Can worn rear shoes affect the handbrake?
Definitely. Worn or poorly adjusted shoes increase handbrake lever travel and reduce holding power. Fresh shoes, a working self-adjuster and a healthy cable restore proper feel and hill-holding.