Parts for your 2001 Daihatsu Gran move-Brake calipers

2001 Daihatsu Gran Move Brake Calipers

Brake calipers are absolutely relevant to the 2001 Daihatsu Gran Move. Technical references including the Daihatsu Gran Move (G300-series) Workshop Manual – Brakes section, the Daihatsu Electronic Parts Catalogue for G301/G303, and major aftermarket catalogues list front disc brake assemblies with floating calipers, while the rear uses drum brakes. That means the Gran Move runs calipers on the front axle only.

On this model, the front brake calipers do the heavy lifting: they squeeze the pads against the rotors to scrub off speed, converting kinetic energy to heat. A well-serviced caliper keeps pedal feel consistent, braking distances short, and front-end stability tidy under hard stops. Because the rear end is drum-braked, the front calipers cop more heat and wear, so keeping them in good nick is key for safe motoring around Aussie and Kiwi roads.

• Common clues they’re due attention: uneven pad wear, pulling to one side under brakes, a hot wheel after short drives, shudder or vibration, a spongy pedal, or brake fluid weeping at the piston seal or hose union.
• Regular service checks: inspect pad thickness and rotor condition, clean and lube slide pins with high-temp brake grease, confirm dust boots are intact, and look for hose cracking or swelling.

When replacement time rolls around, it’s worth fitting quality remanufactured or new calipers in pairs to keep side-to-side performance even. If pistons and bores are clean and within spec, a seal-and-boot rebuild kit can be a cost-effective refresh. Always bleed the system after any caliper or hose work and use the correct brake fluid (DOT 3 or DOT 4 that meets SAE J1703/J1704). Avoid getting grease on pad friction surfaces or rotors, and torque caliper bracket bolts to the specification in the workshop manual.

1. Inspection interval: every 10,000–15,000 km or at each service.
2. Brake fluid: replace every 2 years regardless of kilometres.
3. Post-fitment: bed-in new pads/rotors with a series of moderate stops, then recheck for leaks and even pad contact.

Look after the front calipers on a 2001 Gran Move and the rest of the brake system will thank you with confident, straight-line stopping and fewer surprises in the wet.

Popular questions

Does the 2001 Daihatsu Gran Move have rear brake calipers?
No. The 2001 Gran Move uses front disc brakes with calipers and rear drum brakes. The rear end relies on wheel cylinders inside the drums, not calipers. So if sourcing parts, order calipers only for the front axle.

What are the signs a front caliper is sticking on a Gran Move?
Typical symptoms include the car pulling to one side under braking, a steering wheel shimmy, a hot or discoloured front wheel after a short drive, a burning smell, or noticeably uneven pad wear. You may also feel drag when coasting. If any of these show up, inspect slide pins, piston movement, and hose condition.

Is it better to rebuild or replace the front calipers?
If the caliper body and piston surfaces are clean and within spec, a rebuild with new seals and boots is often fine. If there’s pitting, seized pistons, damaged threads, or repeated sticking, a quality exchange or new caliper is the safer bet. Either way, bleed with fresh DOT 3/4 fluid and verify leak-free operation.