Parts for your 2000 Daihatsu Gran move-Struts

2000 Daihatsu Gran Move struts — what they do and when to sort them

Struts absolutely are relevant on the 2000 Daihatsu Gran Move. Technical sources including the Daihatsu Gran Move/Pyzar chassis workshop manual (G303/G313) and major suspension catalogues from KYB and Monroe specify a MacPherson strut front suspension, with a torsion-beam rear that uses separate coil springs and shock absorbers (not rear struts). So, on this model, “struts” refers to the front units only.

Up front, the MacPherson strut does double duty: it’s the damper that controls bounce and body movement, and it’s also a structural part of the suspension that locates the wheel and sets key alignment angles. On a 2000 Gran Move, healthy front struts keep steering direct, tyre wear even, and the ride settled over corrugations and city potholes alike.

As part of routine servicing, it’s worth having the front struts and top mounts checked every 20,000–30,000 km for leaks, uneven rebound, and play or noise at the bearing plate. In local conditions, many see best performance for 80,000–150,000 km, but plenty need attention earlier if they’ve copped rough roads, heavy loads, or lowered springs.

• Signs they’re tired: front-end float or nose dive, knocking over bumps, tramlining or vague steering, oily film on the strut body, cupped or feathered tyre wear.
• When replacing: always do struts in pairs left/right, fit new dust boots and bump stops, and strongly consider new top mounts/bearings.
• After fitting: book a proper wheel alignment — camber/caster and toe can shift when struts are disturbed.

DIY-savvy owners can tackle the job with a safe spring compressor, quality sockets, and a torque wrench, but it’s not one to wing. The coil spring stores serious energy, use proper compressors and follow the workshop procedure. If in doubt, get a suspension shop to handle the swap and alignment in one go.

Quality replacements (gas-pressurised OE-equivalent) will sharpen steering feel, shorten braking distances by keeping tyres planted, and smooth out choppy ride. It’s a great refresh on an older Gran Move and helps protect new tyres from rapid, uneven wear.

Popular questions about 2000 Daihatsu Gran Move struts

Are the rear dampers on a 2000 Gran Move struts as well?
No — only the front uses MacPherson struts. The rear is a torsion-beam with separate coil springs and conventional shock absorbers. If someone says “rear struts” on this car, they’re usually talking about the rear shocks.

How often should the front struts be replaced?
There’s no fixed interval, but many owners find performance tails off somewhere between 80,000 and 150,000 km. Inspect for leaks, noise, and tyre wear every service or two, and replace on condition or if handling and ride have clearly dropped.

Do you need a wheel alignment after changing front struts?
Yes. Disturbing the strut-to-knuckle bolts and top mount can alter alignment. A post-replacement alignment will protect tyres and restore proper steering feel.