Parts for your 2007 Nissan Navara-Brake shoes

2007 Nissan Navara brake-shoes: what they do and when to replace them

Based on Nissan factory service manuals (D22 and D40 BR sections) and major aftermarket catalogues for Australia and New Zealand (Bendix, Bosch, Repco), the 2007 Nissan Navara uses brake shoes. Most D22 and many D40 variants run rear drum brakes with conventional brake shoes, D40 grades fitted with rear disc brakes still use small drum-style brake shoes inside the disc “hat” for the parking brake. Either way, brake-shoes are relevant on a 2007 Navara.

On a 2007 Navara, the brake shoes handle rear braking on drum-brake models and provide solid handbrake holding on disc-brake models with a drum-in-hat setup. They press outward on the drum’s inner surface to create friction, helping slow the ute and keeping it parked securely on hills—pretty handy when towing or loaded up for site work.

For servicing, it pays to check rear shoes at every major service or around 20,000–30,000 km, especially if the vehicle tows or carries heavy loads. A tech will measure lining thickness, look for glazing or oil contamination, and confirm even wear across both sides. Don’t forget the hardware: return springs, adjusters and wheel cylinders (on drum rears) should be inspected and cleaned or replaced as needed. Fresh brake fluid on schedule also helps keep rear braking consistent.

Common signs the Navara’s shoes are due:

• Longer stopping distances or a low/long pedal travel
• Squeal/scrape from the rear, especially at low speeds
• Handbrake needing more clicks than usual, or weak holding on a slope
• Pulsing or grabby feel from the rear drums

Replacement is typically done in axle pairs, keeping both sides balanced. After fitting, proper shoe adjustment is essential—auto-adjusters need to be correctly set so the first few stops bed things in without dragging. Bedding-in usually involves a handful of gentle stops from suburban speeds to seat the linings to the drum. If the Navara runs rear discs with a drum-in-hat handbrake, the service includes setting the internal shoe-to-drum clearance and adjusting the handbrake cable so it bites firmly without dragging.

Quality shoes matched to the Navara’s load and towing needs, tidy hardware, and correct adjustment will keep braking strong, straight and reliable across Aussie and Kiwi roads.

Popular questions about 2007 Nissan Navara brake-shoes

Do all 2007 Navaras have rear drum brakes?
Many do, particularly D22 and several D40 trims. Some D40 models run rear disc brakes, but still use brake shoes for the drum-in-hat parking brake. Either way, brake-shoes are part of the setup.

How can someone tell their Navara’s brake shoes are worn?
Listen and feel: squeals or scraping from the rear, longer stopping distances, a soft pedal, or a handbrake that needs lots of clicks to hold are common clues. A visual check of lining thickness during service confirms it.

How often should the brake shoes be replaced?
There’s no fixed kilometre figure—driving style, towing and terrain matter. Have them inspected every service, replacement typically happens when linings near minimum thickness, if they’re glazed or contaminated, or if performance drops.