Parts for your 1998 Daihatsu Gran move-Brake hose

1998 Daihatsu Gran Move Brake Hose

Based on the Daihatsu Gran Move/Pyzar (G300-series, often catalogued as M100/M110) workshop manual brake section and the Daihatsu Electronic Parts Catalogue, the 1998 Gran Move uses flexible hydraulic brake hoses at each front caliper and between the body and the rear axle hard-lines. So yes — a brake hose is absolutely relevant and fitted on this vehicle.

The brake hose on a 1998 Daihatsu Gran Move is the flexible link that carries pressurised brake fluid from the rigid body lines to the moving bits: the front calipers and the rear axle circuit. It needs to flex with suspension and steering while holding pressure without swelling or leaking. When the driver hits the pedal, the master cylinder sends fluid down the lines, the hose’s job is to deliver that pressure cleanly so the pads bite hard and consistently.

On a car of this age, hoses deserve special attention during servicing. Rubber degrades over time from heat, road grime, moisture, and brake fluid exposure. Internal lining can collapse, causing brake drag or a spongy pedal. Externally, cracks, perishing, bulges, rusted fittings, or damp patches are red flags to replace straight away.

• Inspection: Check every service (10,000–15,000 km) for cracking, chafe marks, wetness, or corrosion at crimps and brackets.
• Replacement timing: Many techs recommend replacing original-style rubber hoses around 6–10 years or 100,000–150,000 km, sooner if there’s any doubt. On a 1998 vehicle, age alone often justifies renewal.
• Fluid and bleeding: Use the brake fluid grade on the reservoir cap (usually DOT 3 or DOT 4 for this model) and bleed thoroughly after any hose change. Follow ABS bleed procedures if equipped.
• Fitment tips: Use proper flare spanners, cap the open lines, avoid twisting the new hose, and make sure lock tabs/clips and routing are exactly as per factory to prevent chafing. Replace copper washers on banjo bolts and torque to spec.
• Upgrades: ADR/DOT-compliant braided hoses can sharpen pedal feel, provided they’re correctly made and installed by a qualified mechanic.

Signs the Gran Move’s brake hose needs attention include a soft or sinking pedal, pulling under braking, visible leaks, swollen hose sections, or one wheel staying hot after a drive. If any of these show up, it’s time to book it in — fresh hoses and fluid can restore braking bite and confidence.

Does the 1998 Daihatsu Gran Move actually have brake hoses?

Yes. The factory documentation lists flexible front brake hoses to each caliper and a rear flexible hose to the axle. Without them, the suspension and steering couldn’t move while maintaining hydraulic pressure.

How often should brake hoses be replaced on a Gran Move?

Inspect every service and replace at the first sign of ageing or damage. As a rule of thumb, rubber hoses that are 6–10 years old are due, and on a 1998 car, proactive replacement is smart even if they “look” okay.

Are braided brake hoses legal in Australia and New Zealand?

They’re commonly used if they meet the relevant standards (e.g., ADR/DOT) and are installed by a qualified mechanic. Always check local state or WOF/CoF requirements, especially for custom or non-OE lines.